Liquid – Liquid Extraction of Uranium from Sulfate Leach Liquor of Ramlet Hemeyir, Ferruginous Sandstone Ore Material, Southwestern, Sinai, Egypt

nasr abdelaziz abdelfattah, S.M. Mahmoud, H.M. Salman

Abstract


The Ferruginous sandstone ore was obtained from Ramlet Hemeyir area, Southwestern Sinai, Egypt. It was found to contain 0.26 % U and 10 % REE (rare earth elements). A representative sample has been subjected to acid agitation leaching using H2SO4 by which 89% U and 93% REE were released by mixing the sample with concentrated H2SO4 at solid/liquid (S/L) ratio of 1/20 for 5h at a temperature range (250 - 300oC). After precipitation of rare earth elements and lead. Uranium was separated from the filtrate by liquid – liquid extraction using a synergistic system of D2EHPA/TBP in kerosene as a diluent under the following conditions: a solvent concentration of 0.5 M at pH 1, an A/O ratio of 1:1 and a contact time 10 min. The loaded organic solvent was stripped with 10% sodium carbonate at ratio 3:1. Then NaOH was added to the stripped solution to precipitate U-cake at pH 12.0.

 


Keywords


Uranium, Rare Earth Elements, separation, precipitation.

Full Text:

PDF

References


Abdel Wahab, G.M. 2008. Extraction of some nuclear elements from Um-Ghieg Area Red Sea Coast, Egypt, Ph. D. Thesis, Chem. Dep., Fac. Of Sci., Ain Shams Univ., Cairo, Egypt.

Baes Jr., C.F., R.A. Zingaro and C.F. Coleman. 1958. J. Phys. Chem. 62(2) 129.

Brown, A.J., and B.C. Hayden. 1964. A Comparison of Liquid and Resin Ion Exchange Processes for Purification and Concentration of Uraniferous Solutions, Mining Congr.

Bunas FT, Domocos VC and Dumitrescu P, 1978 J Inorg Nucl Chem, 40 (1) 117

Carmen, C. 1986. Recovery of Uranium from Carbonate Leach Liquors Using Weak – Acid Cation Exchange Resins. Reactive Polymers. 4: 77-89.

Daveis, W., and W.A. Gray. 1964. Rapid and Specific Titrametric Method for the Precise Determination of U using FeSO4 as Reductant, Talanta. 11: 1203-1211.

Dry, M. 2009. Water and carbonate balances in an alkalins uranium extraction circuit. Uranium conference, 28- 29 May, Perth, Australia.

Gorecki, H. 1983. TAEA-TC 491/11,Int atomic Energy Agency, Vienna, 197

Gupta, C.K. and H. Singh. 2003 Uranium Resource. Processing Secondary Resources, Springer, Germany.

Habashi, F. 1993. A Textbook of Hydrometallurgy, Laval University, Quebec, Canada.

Lunt, D., P. Boshoff, M. Boyleu, and Z. Ansary. 2007. Uranium extraction : the key process drivers. The journal of the South African institute of Mining and Metallurgy. 107:419- 426.

Marczenko, Z. 1986. Separation and Spectrophotometric Determination of Elements, John Wiley and Sons, Harwood, New York.

Murthy, T.K.S, V.N. Pai, and R.A. Nagle. 1970. Proc. TAEA Symp on Recovery of Uranium, Sao Paulo, TAEA- SM, Vol. 135(11).

Musikasis, C., and W. Sculz. 1992. Principles and practices of solvent extraction, Marcel Dekker Inc., New York, P. 418.

Peppard, D.F.1958. Mason GW, Driscol WJ and Siromen RJ. J. Inorg Nucl Chem.7:276.

Shapiro, L., and W. Brannock. 1962. Rapid Analysis of Silicate, Carbonate and Phosphate Rocks, U.S Geol. Surv. Bull. Vol. 114 A.

Shata, A.E., S.K. Aita, W.A. Hosni, and A.A. El Sayed. 2011. Lithofacies and Radioactivity of the Adedia Formation in Ramlet Hemeyir Area, Southwestern Sinai, Egypt. J. of Sediment. of Egypt. 19:1-12.

Sole, K.C., P.M. Cole, A.M. Feather, and M.H. Kotze. 2011. Solvent extraction and ion exchange application in Africans resurging uranium industry:Areview. Solvent extraction and ion exchange. 29: 868-869.

Viyayalakshmi, R., S.L. Mishra, H. Singh, and C.K. Gupta. 2001. Processing of Xenotime Concentrate by Sulfuric Acid Digestion and Selective Thorium Precipitation for Separation of Rare Earths. Hydrometallurgy. 61: 75-80.


Refbacks

  • There are currently no refbacks.


Copyright (c) 2014 The Journal of Applied Sciences Research

Creative Commons License
This work is licensed under a Creative Commons Attribution-NonCommercial-NoDerivatives 4.0 International License.